1993 FORD F-350

Received 04/02/2008

Defect: FORD IS RECALLING 225,000 MY 1992-2003 ECONOLINE, MY 1993-1995 TAURUS SHO, MY 1992-1998 CROWN VICTORIA, MY 1993 BRONCO, F-SERIES, MY 1995-1997 F-SERIES SUPER DUTY STRIPPED CHASSIS, MY 1992-1998 MERCURY GRAND MARQUIS, AND MY 1992-1995 LINCOLN TOWN CAR VEHICLES. THE AFFECTED VEHICLES WERE PREVIOUSLY REPAIRED USING A WIRING HARNESS THAT IS NOT COMPATIBLE WITH THE VEHICLE CIRCUIT POLARITY.

Consequence: AS A RESULT, THE FUSE IS LOCATED IN THE OUTPUT CIRCUIT RATHER THAN IN THE INTENDED INPUT POWER FEED CIRCUIT, AND MAY NOT OFFER THE INTENDED PROTECTION IN THE EVENT OF AN ELECTRICAL SHORT TO GROUND.

Remedy: DEALERS WILL INSTALL A NEW WIRING HARNESS, OR REPLACE THE MATING ELECTRICAL COMPONENT. THE RECALL BEGAN ON FEBRUARY 18, 2008. OWNERS MAY CONTACT FORD AT 1-800-392-3673.

Received 03/08/2007

Defect: ON CERTAIN PICKUP TRUCKS, PASSENGER VEHICLES, SPORT UTILITY VEHICLES, AND MOTOR HOMES CHASSIS, THE SPEED CONTROL DEACTIVATION SWITCH MAY, UNDER CERTAIN CONDITIONS, LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.

Consequence: THIS COULD RESULT IN AN UNDERHOOD FIRE.

Remedy: DEALERS WILL INSTALL A FUSED WIRING HARNESS. OWNERS OF THE PASSENGER CARS INCLUDED IN THIS CAMPAIGN WILL BE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED AS AN INTERIM REPAIR. AS SOON AS REPAIR PARTS ARE AVAILABLE (EXPECTED OCTOBER 2007), OWNERS WILL BE INSTRUCTED TO RETURN TO THE DEALERS FOR INSTALLATION OF A FUSED WIRING HARNESS. THE RECALL BEGAN ON AUGUST 13, 2007, AND MAILING COMPLETED BY SEPTEMBER 19, 2007. OWNERS MAY CONTACT FORD AT 1-888-222-2751.

Received 24/05/2006

Defect: CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.

Consequence: WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.

Remedy: CK MOTORSPORT WILL NOTIFY OWNERS AND REPLACE THE NONCOMPLIANT LAMPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 1, 2006. OWNERS MAY CONTACT CK MOTORSPORT AT 1-909-610-7211.

Received 22/05/2001

Defect: THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. EQUIPMENT DESCRIPTION: FORD IS REPLACING ALL FIRESTONE WILDERNESS AT 15, 16, AND 17 INCH TIRES MOUNTED ON FORD TRUCKS AND SUVS. FORD REPORTS TREAD SEPARATION CAN OCCUR DUE TO A COMBINATION OF THE SENSITIVITY OF THE TIRE DESIGN TO STRESS, AGING, AND MANUFACTURING DIFFERENCES BETWEEN PLANTS. FORD IS REPLACING THESE TIRES TO PREVENT POSSIBLE PREMATURE TIRE FAILURE. VEHICLE DESCRIPTION: THE VEHICLES LISTED BELOW MAY HAVE BEEN ORIGINALLY EQUIPPED WITH FIRESTONE WILDERNESS AT TIRES OR MAY HAVE HAD WILDERNESS AT TIRES INSTALLED DURING THE FIRESTONE RECALL LAUNCHED IN AUGUST 2000. CERTAIN 1991 THROUGHT 2002 FORD EXPLORER CERTAIN 2001 THROUGHT 2002 EXPLORER SPORT, AND SPORT TRAC CERTAIN 1997 THROUGH 2002 MERCURY MOUNTAINEER CERTAIN 1991 THROUGH 2001 RANGER CERTAIN 1999 THROUGH 2001 EXPEDITION CERTAIN 1991 THROUGH 1994, AND 1997 MODEL YEAR F-SERIES CERTAIN 1991 THROUGH 1994 BRONCO NOTE: BOTH ORIGINAL EQUIPMENT AND REPLACEMENT TIRES ARE AFFECTED.

Consequence: SHOULD THE TREAD SEPARATE AT HIGHWAY SPEEDS, A VEHICLE CRASH COULD OCCUR, POSSIBLY RESULTING IN PERSONAL INJURY OR DEATH.

Remedy: THE REPLACEMENT/REIMBURSEMENT PROGRAM FOR THIS CAMPAIGN EXPIRED ON MARCH 31, 2002. HOWEVER, CUSTOMERS CAN CONTACT FORD AT 1-877-917-3673 OR GO ON-LINE TO WWW.FORD.COM FOR POSSIBLE ASSISTANCE.

Received 29/12/2000

Defect: VEHICLE DESCRIPTION: LIGHT DUTY TRUCKS AND CAB CHASSIS EQUIPPED WITH GASOLINE ENGINES AND DUAL FUEL TANKS. THE CARBON STEEL FUEL PRESSURE REGULATOR IN THE FUEL SYSTEM CAN WEAR OUT DURING THE LIFE OF THE VEHICLE. IF THE FUEL PRESSURE REGULATOR MALFUNCTIONS, IT CAN CAUSE HIGH FUEL SYSTEM PRESSURE, WHICH DAMAGES THE FUEL PUMP CHECK VALVE. THIS ALLOWS FUEL TO BE TRANSFERRED FROM ONE TANK TO THE OTHER, POSSIBLY OVERFILLING THE NON-OPERATING TANK, RESULTING IN FUEL OVERFLOW PAST THE FILLER CAP.

Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A VEHICLE FIRE.

Remedy: DEALERS WILL HAVE A STAINLESS STEEL FUEL PRESSURE REGULATOR INSTALLED. OWNER NOTIFICATION BEGAN JULY 9, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332. (SEE PREVIOUS NHTSA RECALL 93V-125/FORD RECALL 93S68).

Received 19/07/2001

Defect: THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. VEHICLE DESCRIPTION: 1990-1993 FORD F-SERIES VEHICLES EQUIPPED WITH DUAL FUEL TANKS AND 4.9, 5.0,5.8, OR 7.5 LITER GASOLINE FUELED ENGINES. SOME VEHICLES CAN EXPERIENCE A CROSS TANK FUEL FLOW CONDITION DUE TO A DAMAGED CHECK VALVE IN THE FUEL PUMP/SENDER ASSEMBLY. FUEL MAY BE SUPPLIED FROM ONE TANK AND SOME OR ALL OF THE UNUSED FUEL MAY BE RETURNED TO THE OTHER TANK.

Consequence: SHOULD THIS OCCUR, THE CAPACITY OF THE RECEIVING TANK MAY BE EXCEEDED AND FUEL MAY OVERFLOW FROM THE FILLER CAP.

Remedy: FORD IS EXTENDING THE WARRANTY FOR POTENTIAL FUEL CROSS-FLOW TO 12 YEARS OF SERVICE OR 150,000 MILES FROM THE VEHICLE'S WARRANTY START DATE, WHICHEVER OCCURS FIRST. THIS COVER WILL AUTOMATICALLY TRANSFER TO SUBSEQUENT OWNERS AT NO CHARGE. IF A VEHICLE ALREADY HAS MORE THAN 150,000 MILES, THIS OVERAGE WILL LAST UNTIL DECEMBER 31, 2001. IF THE VEHICLE IS EXPERIENCING A FUEL CROSS-FLOW CONDITION, DEALERS WILL REPAIR THE CONDITION FREE OF CHARGE.

Received 02/01/1994

Defect: THE U-CLIP STYLE NUTS THAT RETAIN THE FRONT BUMPERS TO THE FRONT BUMPER INNER ARMS CAN FRACTURE.

Consequence: IF ONE OF THE U-CLIP NUTS FRACTURES, THE BUMPER WILL LOOSEN AND RATTLE CAUSING FRACTURE OF THE REMAINING U-CLIP NUTS, RESULTING IN SEPARATION OF THE BUMPER FROM THE VEHICLE. IF THE BUMPER WERE TO DETACH FROM THE VEHICLE WHILE IT IS BEING DRIVEN, A VEHICLE COLLISION COULD RESULT.

Remedy: INSPECTION AND REPLACEMENT OF THE FOUR U-CLIP NUTS AND THE ASSOCIATED BOLTS.

Received 02/08/1993

Defect: A MALFUNCTIONING CHECK VALVE WITHIN THE FUEL PUMP ASSEMBLY CAUSES A PORTION OF THE UNUSED FUEL FROM ONE TANK TO BE RETURNED TO THE SECOND TANK. WHEN THIS OCCURS, THE CAPACITY OF THE SECOND TANK CAN BE EXCEEDED, CAUSING FUEL SPILLAGE.

Consequence: SPILLED FUEL CAN RESULT IN A FIRE WHEN EXPOSED TO ASOURCE OF IGNITION.

Remedy: REPLACEMENT OF THE FUEL PRESSURE REGULATOR AND INSTALLATION OF REDUNDANT CHECK VALVES.

Received 07/09/1994

Defect: THE PARKING BRAKE CONTROL SELF-ADJUST PAWL DOES NOT LINE UP PROPERLY WITH THE SELF-ADJUST RACHET CAUSING THE PAWL TO SLIP OVER ONE OR MORE TEETH IN THE RACHET.

Consequence: WHEN THE ABOVE OCCURS, IT CAN RESULT IN PARKING BRAKE SYSTEM INEFFECTIVENESS. THE PARKING BRAKE WILL NOT HOLD THE VEHICLE, CAUSING THE VEHICLE TO ROLL FREELY, IF THE TRANSMISSION IS NOT LEFT IN GEAR.

Remedy: A WEDGE WILL BE INSTALLED WHICH WILL SERVE TO LOCK THE PARKING BRAKE SELF-ADJUST MECHANISM PAWL INTO ENGAGEMENT WITH THE RACHET. ALSO, OWNERS WILL BE ADVISED TO RELEASE AND REAPPLY THE PARKING BRAKE WHENEVER TOOTH SKIP OCCURS AND WILL BE REMINDED TO ALWAYS TURN OFF THE ENGINE AND LEAVE THE VEHICLE IN GEAR WHEN THE VEHICLE IS PARKED.

Incident 03/15/2013 · Filed 03/29/2016

TL* THE CONTACT OWNS A 1993 FORD F-350 EQUIPPED WITH BCT HI-RUN TIRES, SIZE L235/85R16 (NA). WHILE DRIVING APPROXIMATELY 65 MPH, THE FRONT DRIVER SIDE TIRE BLEW OUT. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE TIRE TREADS WERE SEPARATING FROM THE TIRES AND THE TIRES NEEDED TO BE REPLACED. WHILE AT THE INDEPENDENT MECHANIC, THE OTHER THREE TIRES BLEW OUT. THE TIRES WERE NOT REPAIRED. THE TIRES WERE NOT ORIGINAL EQUIPMENT. THE MANUFACTURER WAS NOTIFIED OF THE FAILURES. THE APPROXIMATE VEHICLE FAILURE MILEAGE WAS 190,000 AND THE TIRE FAILURE MILEAGE WAS 4,000. THE VIN AND DOT NUMBER WERE NOT PROVIDED.

Incident 09/10/2015 · Filed 11/04/2015

HAD BOTH OF MY STEER TIRES BLOW OUT GOING DOWN THE HIGH WAY RIGHT SIDE I HAD A TRAILER ON AND THE OTHER I HAD JUST GOT ON TO THE INTERSTATE. PUT A HOLE IN MY FLOOR ON DRIVERSIDE AND BROKE THE BRAKE LINE ON THE DRIVERSIDE AS WELL. PASSENGER SIDE JUST LET LOOSE WITH NO WARNING. I STILL HAVE ALL FOUR TIRES AND THE TREAD. THESE WERE 235/85R16

Incident 05/10/2004 · Filed 03/22/2009

MY FORD F350 CREWCAB CAUGHT ON FIRE FOR NO APPARENT REASON. I AM JUST NOW FINDING OUT THAT THERE IS A RECALL ON MY VEHICLE BECAUSE OF SPONTANEOUS FIRES ON MY YEAR AND MODEL. I SPENT ALMOST $3000.00 ON REPAIRS AND HAVE BEEN HAVING ONGOING PROBLEMS WITH THE ENGINE QUITTING WHILE DRIVING. I WOULD LIKE TO KNOW IF THERE IS ANY REMEDY THAT I CAN OBTAIN FROM FORD. I HAVE NOT BEEN ABLE TO USE THIS TRUCK FOR OVER 2 YEARS BECAUSE OF THE ENGINE QUITTING AND THEN A NO START SITUATION. VEHICLE WILL START AFTER IT COOLS DOWN BUT WILL STOP WITHIN A HALF HOUR.THIS IS FRUSTRATING BECAUSE THIS IS MY ONLY VEHICLE AND I HAVE LOST USE OF THE TRUCK AND HAD TO STOP WORKING BECAUSE I AM A CONSTRUCTION CONTRACTOR AND NEEDED IT TO WORK. I HAVE HAD THE TRUCK TO THE DEALER NUMEROUS TIMES. AFTER RESEARCHING PROBLEMS ONLINE I HAD ONLY FOUND OUT THEN ABOUT POSSIBLE UNDERHOOD FIRES ON MY VEHICLE. I ALSO FOUND OUT ABOUT OTHER TSB AND RECALL INFORMATION OF WHICH I HAD NOT BEEN NOTIFIED. *TR

Fire

Incident 02/20/2009 · Filed 02/25/2009

1993 FORD F-350 WITH A 5.8 ENGINE, I RECEIVED THIS INFO. FROM ALLDATA. I READ ON FORD'S WEB SITE THAT A SAFETY RECALL GENERALLY NEVER EXPIRES... RECALL #'S 00S57 FUEL PRESSURE REGULATOR REPLACEMENT, # 00V424000 FUEL PRESSURE REGULATOR MALFUNCTION, # 01L008000 FUEL PUMP CHECK VALVE DEFECT., ALL THREE OF THESE HAVE THE SAME SYMPTOMS, CAUSES FUEL FROM THE REAR TANK TO TRANSFER TO THE FRONT TANK AND CAUSE FUEL TO RUN OUT OF THE FUEL FILLER NECK OF THE FRONT TANK AND DOWN THE SIDE OF THE TRUCK ONTO THE GROUND. I HAVE OWNED THE TRUCK FOR 6 YEARS AND HAVE NEVER RECEIVED ANY TYPE OF NOTICE FOR THIS, ONE NOTICE STATES THAT VEHICLE OWNERS WOULD BE NOTIFIED STARTING MAY 2001, FORD SENT ME AN EMAIL TODAY STATING THAT THEY WOULD NOT REPAIR THIS, I EVEN SENT THEM THE RECALL #'S, I HOPE THAT YOU CAN OFFER ME SOME HELP ON THIS, AS I REALLY DO NOT WANT MY TRUCK TO CATCH FIRE WITH OR WITHOUT MY FAMILY IN IT. THANK YOU *TR UPDATED 03/06/09. *JB

Incident 08/13/1998 · Filed 08/13/2008

TL*THE CONTACT OWNS A 1993 FORD F350. THE CONTACT STATED THAT THE PARKING BRAKE SYSTEM WAS INEFFECTIVE. THE PARKING BRAKE DOES NOT HOLD THE VEHICLE AND CAUSES IT TO ROLL FREELY. HE TOOK THE VEHICLE TO THE DEALER ON TWO OCCASIONS AND THEY REPLACED THE BRAKE CABLES TWICE AT THE COST OF $300 EACH. WHEN THE FAILURE RESURFACED, THE CONTACT CALLED THE MANUFACTURER IN REFERENCE TO NHTSA CAMPAIGN ID NUMBER 94V169001 (PARKING BRAKE:CONVENTIONAL) AND WAS INFORMED THAT HIS VIN WAS NOT INCLUDED IN THE RECALL. THE CONTACT WOULD BE RESPONSIBLE FOR THE REPAIRS. THE FAILURE MILEAGE WAS 45,000 AND CURRENT MILEAGE WAS 202,000.

Incident 11/13/2007 · Filed 11/13/2007

WE OWN A 1993 FORD F350. IT WAS PARKED IN FRONT OF OUR HOUSE ATTACHED GARAGE. IT WAS NOT RUNNING. MY HUSBAND WENT OUTSIDE AND WALKED BETWEEN THE TRUCK AND GARAGE. HE SMELLED SMOKE, LOOKED TOWARD THE PICKUP AND SAW SMOKE COMING OUT FROM UNDER THE HOOD. HE QUICKLY RAISED THE HOOD AND PUT THE FIRE OUT. OUR CRUISE CONTROL HAD NOT BEEN WORKING FOR SOME TIME. MY HUSBAND PURCHASED THE SWITCH FROM CANTON MOTORS AND REPLACED IT. THE CRUISE CONTROL WORKED AGAIN, FOR AWHILE. IT HAS NOT CAUGHT ON FIRE AGAIN, YET BUT I'M AFRAID WE HAVE ANOTHER DEFECTIVE SWITCH. FORD HAS A RECALL ON 1993 PICKUPS NOW FOR THAT PROBLEM BUT WHEN I CHECKED OUR VIN, IT STATES THERE IS NO RECALL ON IT. I BELIEVE THAT FORD SHOULD REIMBURSE US FOR THE SWITCH WE PURCHASED AND REPLACE IT. THE FIRST SWITCH IS POSSIBLY AVAILABLE. THE CURRENT ONE IS STILL ON THE PICKUP. I TALKED TO FORD CUSTOMER SERVICE TO RESOLVE THIS PROBLEM BUT NO HELP WAS OFFERED AND THE LADY WAS RATHER RUDE. I DO NOT REMEMBER THE DATE OF THE FIRE. THE CRUISE CONTROL DOES NOT WORK NOW. *TR

Fire

Incident 08/26/2006 · Filed 08/28/2006

DT*: THE CONTACT STATED WHILE DRIVING 60 MPH ON THE INTERSTATE IN NORMAL ROAD CONDITIONS, THE LEFT INNER DUALLY TIRE TREAD SEPARATED WITHOUT WARNING. THE CONTACT MANAGED TO PULL OVER WITHOUT INCIDENT. UPON INITIAL INSPECTION, THE CARCASS OF THE TIRE REMAINED INFLATED, YET THE TREAD WAS COMPLETELY SEPARATED. THERE WAS DAMAGE TO THE FUEL LINES FROM THE INITIAL TIRE TREAD SEPARATION. THERE WERE NO OBVIOUS ROAD HAZARD OR DEBRIS. THE MANUFACTURER WAS NOT ALERTED. THE TIRE WAS A BRIDGESTONE LT 215/85/R16, LOAD RANGE E. UPDATED 03/30/07. *JB

Incident 07/22/2006 · Filed 07/24/2006

I WAS USING MY REAR GAS TANK IN MY DUAL TANK SYSTEM. THE FUEL ,IN ADDITION TO OPERATING THE VEHICLE, PUMPED INTO THE HALF FULL FRONT TANK. WHEN I WENT TO FILL THE FRONT TANK AT THE FILLING STATION, THE FUEL FORCIBLY SPILLED OUT OF THE FRONT TANK, SPRAYING ON ME. *NM

Incident 07/15/2005 · Filed 08/22/2005

TIRE TREAD SEPARATION ON LOW MILEAGE TIRE. TIRE MODEL WILD COUNTRY APT LT235/85R-16. MILEAGE VERIFIED AT 21,152MI. VEHICAL DAMAGE DUE TO TIRE TREAD IMPACTING AUTO AND BRAKE LINES. NO INJURIES. TIRE WAS A REAR TIRE, SO WE HAD TO REPLACE BOTH TIRES.

Incident 08/17/2005 · Filed 08/18/2005

CLUTCH SLAVE CYLINDER TOO CLOSE TO EXHAUST AND OVER HEATS O-RING CAUSING LOSS OF BRAKE FLUID AND LOSS OF CLUTCH. LESS THAN 50,000 MILES ON TRUCK AND IS USED FOR TOWING 5TH WHEEL RV SOME TIMES IN MOUNTAINS IT HAS WENT OUT TWO TIMES NOW ONCE ABOUT TWO YEARS AGO AND JUST TODAY, 08/17/2005. HEAT INSULATOR WAS IN PLACE BOTH TIMES. *JB